Skip to main content

Indmar GM V-8 Inboards 8.2L (1983 - 2003)

700+ pictures of your vehicle
Extra videos in online manual
View online on any device (not a download)
The original Haynes Repair Manual - Based on a complete stripdown and rebuild of a vehicle

Indmar GM V-8 Inboards 8.2L (1983 - 2003)

Online OnlyAu $79.95Au $44.95
Print OnlyAu $79.95Au $54.95
This is an online only product
What's Covered
Open Close

This Indmar manual is 480 pages.

QUICK REFERENCE DATA

CHAPTER ONE / GENERAL INFORMATION
Manual organization / Warnings, cautions and notes / Safety / Model identification / Engine operation / Fasteners / Shop supplies / Galvanic corrosion / Propellers / Basic tools / Special tools / Precision measuring tools / Electrical system fundamentals / Basic mechanical skills / Specifications

CHAPTER TWO / TROUBLESHOOTING
Preliminary inspection / Electric starting system / Charging system / Ignition system / Basic fuel system troubleshooting / Electronic fuel injection (EFI) system / Diagnostic trouble codes (DTC) / Power steering system / Cooling system / Warning system / Engine / Drive system / Specifications

CHAPTER THREE / LUBRICATION, MAINTENANCE AND TUNE-UP
Before each use / Engine oil level check / Transmission fluid and V-Drive unit fluid level check / Coolant level check / Emergency stop (lanyard) switch operation / After each use / Lubrication / Engine oil and filter change / Transmission fluid change / Steering cable lubrication / Check engine alignment / Fuel system maintenance / Fuel requirements / Fuel filter service / Flame arrestor service / PCV valve service / Engine coolant / Draining coolant / Coolant replacement / Tune-up / Compression test / Spark plugs / Distributor cap, plug wires and rotor / Breaker points and condenser replacement / Breaker point gap and dwell adjustment / Valve adjustment / Carburetor adjustment / Ignition timing adjustment / Water testing the engine / Submersion / Specifications

CHAPTER FOUR / LAY-UP, WINTERIZING AND FITTING OUT
Lay-up / Winterizing / Fitting out

CHAPTER FIVE / ADJUSTMENTS
Carburetor / Ignition timing adjustment / Shift cable adjustment / Throttle cable adjustment / Specifications

CHAPTER SIX / ENGINE
Engine operation / Special tools / Replacement parts / Special service precautions / Engine removal and installation / Engine alignment / Rocker arm cover / Valve adjustment / Top dead center (TDC) firing position / Camshaft lobe lift / Rocker arm and pushrod / Cylinder head / Valves and valve seats / Oil pan / Oil pump / Harmonic balancer / Timing cover / Timing gear, chain and sprockets / Camshaft and lifters / Pistons and connecting rods / Flywheel housing, flywheel and drive plate / Rear main seal / Crankshaft and main bearings / Break-in procedure / Specifications

CHAPTER SEVEN / FUEL SYSTEMS
Servicing the fuel system / Fuel pump and filter replacement / Carburetor / Electronic fuel injection (EFI) / Intake manifold / Specifications

CHAPTER EIGHT / COOLING AND EXHAUST SYSTEM
Thermostat / Hose replacement / Recirculation pump removal and installation / Seawater pump / Transmission fluid, power steering fluid and oil coolers / Exhaust elbow, riser and manifold / Specifications

CHAPTER NINE / ELECTRICAL SYSTEM
Battery / Alternator / Starter motor and solenoid / Distributor and ignition system components / Senders, switches and warning system components / Electronic fuel injection (EFI) components / Specifications

CHAPTER TEN / DRIVE SYSTEM
Transmission / Walters V-Drive Unit / Propeller / Specifications

CHAPTER ELEVEN / STEERING SYSTEM
Safety precautions / Mechanical (manual) steering system / Power steering system / Specifications

CHAPTER TWELVE / REMOTE CONTROL INDEX

COLOR WIRING DIAGRAMS

Models covered: Includes LT-1 engines
5.0 L
5.7 L
7.4 L
8.1 L
8.2 L
1983 1984 1985 1986 1987 1988 1989 1990 1991 1992 1993 1994 1995 1996 1997 1998 1999 2000 2001 2002 2003

Clymer Manuals 5.0 L Manual
Clymer Manuals 5.7 L Manual
Clymer Manuals 7.4 L Manual
Clymer Manuals 8.1 L Manual
Clymer Manuals 8.2 L Manual

Indmar 5.0 L (1983-2003)
Indmar 5.7 L (1983-2003)
Indmar 7.4 L (1983-2003)
Indmar 8.1 L (1983-2003)
Indmar 8.2 L (1983-2003)

Includes LT-1 engines

About Haynes Manuals
Open Close