Skip to main content

Polaris Water Vehicles SL650 to SLT750 (1992 - 1995)

700+ pictures of your vehicle
Extra videos in online manual
View online on any device (not a download)
The original Haynes Repair Manual - Based on a complete stripdown and rebuild of a vehicle

Polaris Water Vehicles SL650 to SLT750 (1992 - 1995)

Online OnlyAu $79.95Au $49.95
Print OnlyAu $59.95Au $44.95
This is an online only product
What's Covered
Open Close

This Polaris PWC manual is 488 pages.

QUICK REFERENCE DATA

CHAPTER ONE / GENERAL INFORMATION
Manual organization / Notes, cautions and warnings / Safety first / Service hints / Engine operation / Clearing a submerged Jet Ski / Torque specifications / Fasteners / Lubricants / RTV Gasket sealant / Threadlocking compound / Parts replacement / Basic hand tools / Special tools / Mechanicâ??s tips /Specifications

CHAPTER TWO / TROUBLESHOOTING
Operating requirements / Troubleshooting tools / Starting system / Charging system / Ignition system / Stop switch relay / Fuel system / Engine / two-stroke pressure testing / Steering

CHAPTER THREE / LUBRICATION, MAINTENANCE AND TUNE-UP
Operational checklists / Pre ride daily inspection / Post ride inspection / End of day checklist / Break in / 10-hour inspection / Pre-season check up / Fuel and lubrication / Service intervals / Periodic maintenance / Fuel filter / Injection oil filter change / Engine stop switch and tether / Engine overheat buzzer warning / Steering jet pump alignment check / Intake grate / Cooling filters and thermostat / Control cable adjustment / Synchronize carb choke valves / General inspection and maintenance / Tune-up / Cylinder head bolt torque / Cylinder compression check test / Spark plug / Ignition timing / Idle speed adjustment / Specifications

CHAPTER FOUR / ENGINE
Engine lubrication / Service precautions / Servicing the engine in the hull / Special tools / Precautions / Engine removal / Engine support plate and rubber mounts / Engine installation / Engine jet pump alignment / Exhaust pipe and manifold / Engine top end / Cylinders / Piston, piston pin and piston rings / Crankcase and crankshaft / Rear coupling / Specifications

CHAPTER FIVE / DRIVE SYSTEM
Service precautions / Jet pump / Driveshaft bearing, seals and housing / Electric quick trim system / Specifications

CHAPTER SIX / FUEL SYSTEM
Fuel system identification / Air intake silencer and flame arrestor / Carburetors / Automatic shutoff valve / Manual shutoff valve / Fuel pump / Reed valves / Fuel gauge / Fuel tank / Specifications

CHAPTER SEVEN / ELECTRICAL SYSTEM
Battery / Ignition system / Electrical box / Charging system / Starting system / Electric trim / Instruments / Specifications

CHAPTER EIGHT / OIL INJECTION SYSTEM
System components / Oil pump service / Component replacement / Specifications

CHAPTER NINE / COOLING SYSTEM
Hoses / Maintenance / Component replacement / Specifications

CHAPTER TEN / STEERING SYSTEM
Component replacement / Specifications

CHAPTER ELEVEN / OFF-SEASON STORAGE
Storage / Specifications

INDEX

WIRING DIAGRAMS

Models covered:
1992 1993 1994 1995 Polaris SL650
1992 1993 1994 1995 Polaris SL650 Std.
1992 1993 1994 1995 Polaris SL750
1992 1993 1994 1995 Polaris SLT750

Clymer Manuals Polaris SL650 Manual
Clymer Manuals Polaris SL650 Std. Manual
Clymer Manuals Polaris SL750 Manual
Clymer Manuals Polaris SLT750 Manual
Clymer Manuals Polaris SL650 Online Manual
Clymer Manuals Polaris SL650 Std. Online Manual
Clymer Manuals Polaris SL750 Online Manual
Clymer Manuals Polaris SLT750 Online Manual

SL650 (1992-1995)
SL650 Std. (1992-1995)
SL750 (1992-1995)
SLT750 (1992-1995)

About Haynes Manuals
Open Close