Harley-Davidson FLTRSE3 Screaming Eagle Road Glide (2009) Clymer

This Harley-Davidson Manual is 740 pages.

QUICK REFERENCE DATA

CHAPTER ONE/ GENERAL INFORMATION
Manual organization / Warnings, cautions and notes / Safety / Serial numbers / Fasteners / Shop supplies / Tools / Measuring tools / Electrical system fundamentals / Service methods / Storage / Specifications

CHAPTER TWO / TROUBLESHOOTING
Engine starting / Engine performance / Engine noises / Electrical testing / Starting system / Charging system / Ignition system / Fuel system (carbureted models) / Fuel system (electronic fuel injection) / Engine lubrication / Clutch / Transmission / Lighting system / Excessive vibration / Front suspension and steering / Brake problems / Electronic diagnostic system / Cruise control system diagnostic trouble codes / Specifications

CHAPTER THREE / LUBRICATION, MAINTENANCE AND TUNE-UP
Maintenance intervals / Pre-ride inspection / Tires and wheels / Screamin' Eagle lubrication / Engine oil and filter / Transmission oil / Primary chaincase oil / Front fork oil / Control cables / Primary chain and drive belt / Brake system / Clutch system / Fuel system / Air filter / Suspension and fasteners / Compression test / Spark plugs / Ignition timing / Idle speed adjustment / Vehicle alignment (2006-2008 models) / Specifications

CHAPTER FOUR / ENGINE TOP END AND EXHAUST SYSTEM
Engine service precautions / Servicing engine in frame / Rocker arms, pushrods and valve lifters / Cylinder head / Valves and valve components / Cylinder / Pistons and piston rings / Pushrods / Exhaust system / Active exhaust / Specifications

CHAPTER FIVE / ENGINE LOWER END
Engine / Oil pump / Oil filter mount (2006 models except Screamin¿ Eagle) / Oil cooler, oil filter mount and thermostat / Camshaft support plate / Crankcase and crankshaft / Crankcase bearing replacement / Engine break-in / Specifications

CHAPTER SIX / CLUTCH AND PRIMARY DRIVE
Primary chaincase cover / Primary chaincase housing / Clutch assembly / Clutch pushrod and release plate inspection (Screamin¿ Eagle models) / Primary drive assembly (2006 models) / Primary chain alignment (2006 models) / Primary drive assembly (2007-2009 models) / Clutch shell, hub and sprocket / Primary chain and tensioner inspection (all models) / Compensating sprocket inspection / Starter jackshaft (2006 models) / Clutch cable replacement (all models except Screamin¿ Eagle) / Clutch lever assembly (all models except Screamin¿ Eagle) / Clutch release cover (all models except Screamin¿ Eagle) / Clutch service (Screamin¿ Eagle models) / Clutch master cylinder (Screamin¿ Eagle models) / Clutch release cover (Screamin¿ Eagle models) / Clutch secondary actuator (Screamin¿ Eagle models) / Clutch hydraulic hose replacement / (Screamin¿ Eagle models) / Clutch system flushing (Screamin¿ Eagle models) / Clutch system draining (Screamin¿ Eagle models) / Clutch system bleeding (Screamin¿ Eagle models) / Specifications

CHAPTER SEVEN / FIVE SPEED TRANSMISSION (2006 MODELS)
Shift assembly / External shift mechanism / Transmission cover / Shift cam / Shift arm assembly / Shift forks / Transmission side door assembly / Transmission shafts / Side door bearings / Main drive gear / Drive sprocket / Transmission case / Oil pan / Specifications

CHAPTER EIGHT / SIX SPEED TRANSMISSION (2007-2009)
Shift assembly / External shift mechanism / Transmission cover / Shift arm assembly / Shift forks and shift cam / Transmission side door assembly / Transmission shafts / Side door bearings / Main drive gear / Transmission drive sprocket / Transmission case / Oil pan / Specifications

CHAPTER NINE / AIR/FUEL AND EMISSION CONTROL SYSTEMS (CARBURETED MODELS)
Air filter and backplate / Carburetor / Intake manifold / Throttle and idle cables (2006-2007 non-cruise control models) / Starting enrichment valve (choke) cable replacement / Fuel tank console / Fuel tank / Fuel shutoff valve / Fuel level sender (canopy) / Evaporative emission control system (carbureted and fuel-injected models) / Specifications

CHAPTER TEN /AIR/FUEL AND EMISSION CONTROL SYSTEMS (FUEL INJECTED MODELS)
Air filter and backplate (all models except 2007 FLHRSE3 and 2009 FLTRSE3) / Air filter and backplate (2007 FLHRSE3 and 2009 FLTRSE3 domestic models) / Depressurizing the fuel system / Fuel tank / Fuel supply check valve / Fuel pump/level sender assembly (2006-2007 models) / Fuel pump and fuel filter (2008-2009 models) / Fuel pressure test (2008-2009 models) / Fuel tank console / Electronic fuel injection (EFI) / Throttle and idle cables (2006 and 2007 non-cruise control models) / Throttle and idle cables (2006 and 2007 cruise control models) / Throttle control actuator (TCA) (2008-2009 models) / Throttle or twist grip sensor (2008-2009 models) / Twist grip sensor jumper wire (2008-2009 models) / Induction module / Fuel injectors / Induction module sensors / Evaporative emission control system (all California models) / Specifications

CHAPTER ELEVEN / ELECTRICAL SYSTEM
Electrical component replacement / Fuses / Maxi-Fuse / Battery / Battery tray / Charging system / Alternator / Voltage regulator / Ignition system / Ignition coil / Ignition control module (ICM) (carbureted models) / Electronic control module (ECM) (fuel injected models) / Electrical bracket (2006-2007 models) / Electrical caddies (2008-2009 models) / Sensors / Starting system / Starter / Lighting system / Headlight / Passing lights and front turn signals / Turn signals / Taillight/brake light / Fender tip light / Rear fascia light / License plate light / Tour-pak / Instruments / Automatic compression release solenoid (2006-2009 Screamin¿ Eagle models) / Switches / Horn / Turn signal security module (TSM, TSSM and HFSM) / Security siren (optional on 2007-2009 models) / Radio (storage box) / Radio antenna / Front fairing speakers / Front headset receptacle (2008-2009 FLHTCUSE models) / Rear passenger switches / Rear speakers / CB module (FLHTCU models) / Relays / Electrical connector location and identification / Electrical connector service / Autofuse electrical connectors / Sealed butt connectors / Wiring diagrams / Specifications

CHAPTER TWELVE / WHEELS, HUBS AND TIRES
Motorcycle stands / Front wheel / Rear wheel / Front and rear hubs / Driven sprocket assembly / Drive sprocket / Drive belt / Laced wheel service / Wheel balance / Tire changing (laced wheels) / Tire changing (alloy wheels) / Tire repairs / Specifications

CHAPTER THIRTEEN / FRONT SUSPENSION AND STEERING
Handlebar / Front fork / Steering head and stem / Steering head bearing race replacement / Steering play inspection and adjustment / Specifications

CHAPTER FOURTEEN / REAR SUSPENSION
Shock air pressure adjustment / Air pressure loss inspection / Shock absorbers / Rear swing arm / Specifications

CHAPTER FIFTEEN / BRAKES
Brake service / Front brake pad replacement / Front brake caliper / Front master cylinder / Rear brake pad replacement / Rear brake caliper / Rear master cylinder and rear brake pedal (all models) / Rear master cylinder service / Brake hose and line replacement (non-ABS models) / ABS brake system / ABS wheel speed sensors / ABS brake module / ABS diode pack / Brake line replacement (ABS models) / Brake disc / Brake bleeding / Flushing the brake system / Specifications

CHAPTER SIXTEEN / CRUISE CONTROL
System components and operation / Control cables adjustment (2006-2007 models) / Control cables replacement (2006-2007 models) / Cruise control module (2006-2007 models) / Cruise control switches / Specifications

CHAPTER SEVENTEEN / BODY AND FRAME
Seats / Rider and passenger backrests / Rear frame rails / Front fender / Rear fender / Rear fender fascia / License plate bracket / Windshield / Front fairing / Frame side covers / Saddlebags / Saddlebag supports/guards / Engine guard / Jiffy stand / Tour-pak / Footboards and highway foot pegs / Specifications

Index

Color Wiring Diagrams on CD

Diagnostic Flow Charts on CD

Models Covered:
FLHT Electra Glide Standard (2006 2007 2008 2009)
FLHTI Electra Glide Standard (2006)
FLHTC Electra Glide Classic (2007 2008 2009)
FLHTCI Electra Glide Standard (2006)
FLHTCU Ultra Classic Electra Glide (2007 2008 2009)
FLHTCUI Ultra Classic Electra Glide (2006)
FLHTCUSE Screamin Eagle Ultra Classic Electra Glide (2006)
FLHTCUSE2 Screamin Eagle Ultra Classic Electra Glide (2007)
FLHTCUSE3 Screamin Eagle Ultra Classic Electra Glide (2008)
FLHTCUSE4 Screamin Eagle Ultra Classic Electra Glide (2009)
FLHR Road King (2006 2007 2008 2009)
FLHRI Road King (2006)
FLHRS Road King Custom (2006 2007)
FLHRSI Road King Custom (2006)
FLHRC Road King Classic (2007 2009)
FLHRCI Road King Classic (2006)
FLHRSE3 Screamin Eagle Road King (2007)
FLHRSE4 Screamin Eagle Road King (2008)
FLHX Street Glide (2006 2007 2008 2009)
FLHXI Street Glide (2006)
FLTR Road Glide (2007-2009)
FLTRI Road Glide (2006)
FLTRSE3 Screamin Eagle Road Glide (2009)