![Free shipping over £30](https://haynes.com/en-gb/sites/all/modules/contrib/lazyloader/image_placeholder.gif)
![Free shipping over £30](https://haynes.com/en-gb/sites/all/modules/contrib/lazyloader/image_placeholder.gif)
This Suzuki marine manual is 437 pages.
QUICK REFERENCE DATA
CHAPTER ONE / GENERAL INFORMATION
Manual organization / Notes, cautions and warnings / Torque specifications / Engine operation / Fasteners / Lubricants / Gasket sealants / Galvanic corrosion / Protection from galvanic corrosion / Propellers / Specifications
CHAPTER TWO / TOOLS AND TECHNIQUES
Safety first / Basic hand tools / Test equipment / Service hints / Special tips / Mechanic's techniques / Specifications
CHAPTER THREE / TROUBLESHOOTING AND TESTING
Outboard engine identification / Troubleshooting test equipment / Troubleshooting preparation / Starting difficulty / Fuel system / Starting system / Charging system / Ignition system / Warning system / Fuses and wire harness / Wire harness / Power head / Cooling system / Gearcase / Trim system / Electronic fuel injection / Specifications
CHAPTER FOUR / LUBRICATION, MAINTENANCE AND TUNE-UP
Before and after each use / Check engine oil level / Check for fuel and oil leaks / Engine mounting hardware inspection and torque / Propeller inspection / Cooling system flush / Routine power head maintenance / Engine oil change / Oil filter replacement / Timing belt inspection / Valve adjustment / Hoses and clamps inspection / Spark plug inspection / Throttle and shift linkage inspection / Fastener inspection / Timing and fuel system adjustments / Battery service / Power head anode inspection / Midsection maintenance / Swivel and tilt pin lubrication / Steering cable lubrication / Anode inspection / Ground wire inspection / Gearcase maintenance / Gearcase lubricant change / Propeller shaft and nut lubrication / Anode inspection / Storage preparation / Submersion / Corrosion maintenance / Tune-up / Ignition timing check / Compression check / Carburetor adjustment / On-boat testing / Specifications
CHAPTER FIVE / SYNCHRONIZATION AND ADJUSTMENT
Valve adjustment / Throttle cable and linkage adjustment / Shift cable and linkage adjustment / Carburetor synchronization (DF25 and DF30 models) / Pilot screw adjustment / Idle speed adjustment / Choke solenoid and choke linkage / Dashpot adjustment / Neutral-only start cable / Trim position sender / Trim tab / Specifications
CHAPTER SIX / FUEL SYSTEM
Fuel system service precautions / Low pressure fuel pump / Silencer cover / Carburetor removal and installation / Carburetor overhaul / Fuel injection system / Specifications
CHAPTER SEVEN / ELECTRICAL AND IGNITION
Starting system / Charging system / Ignition system / Warning system / Battery maintenance / Specifications
CHAPTER EIGHT / POWER HEAD
Flywheel / Power head removal/installation/repair / Cylinder head / Cylinder block component removal / Cylinder block disassembly / Cylinder block cleaning / Cylinder block inspection and maintenance / Cylinder block assembly / Break-in procedure / Specifications
CHAPTER NINE / GEARCASE
Gearcase shim selection / Gearcase shim adjustments / Specifications
CHAPTER TEN / MANUAL STARTER
Manual starter / Specifications
CHAPTER ELEVEN / HYDRAULIC TRIM AND MIDSECTION
Trim system / Midsection / Specifications
CHAPTER TWELVE / REMOTE CONTROL
INDEX
WIRING DIAGRAMS
Models covered:
1997 1998 1999 2000 Suzuki DF9.9
1997 1998 1999 2000 Suzuki DF15
1997 1998 1999 2000 Suzuki DF25
1997 1998 1999 2000 Suzuki DF30
1997 1998 1999 2000 Suzuki DF40
1997 1998 1999 2000 Suzuki DF50
1997 1998 1999 2000 Suzuki DF70
Clymer Manuals Suzuki DF9.9 Manuals
Clymer Manuals Suzuki DF15 Manuals
Clymer Manuals Suzuki DF25 Manuals
Clymer Manuals Suzuki DF30 Manuals
Clymer Manuals Suzuki DF40 Manuals
Clymer Manuals Suzuki DF50 Manuals
Clymer Manuals Suzuki DF70 Manuals
Clymer Manuals Suzuki DF9.9 Online Manuals
Clymer Manuals Suzuki DF15 Online Manuals
Clymer Manuals Suzuki DF25 Online Manuals
Clymer Manuals Suzuki DF30 Online Manuals
Clymer Manuals Suzuki DF40 Online Manuals
Clymer Manuals Suzuki DF50 Online Manuals
Clymer Manuals Suzuki DF70 Online Manuals
Suzuki DF9.9 (1997-2000)
Suzuki DF15 (1997-2000)
Suzuki DF25 (1997-2000)
Suzuki DF30 (1997-2000)
Suzuki DF40 (1997-2000)
Suzuki DF50 (1997-2000)
Suzuki DF70 (1997-2000)